Thread Rating:
  • 0 Vote(s) - 0 Average
  • 1
  • 2
  • 3
  • 4
  • 5
Cleaning the Devialet
#20
Hi,
The surface treatment is NOT chrome! I would not recommend any polishing agent at all. Any glass cleaners I suggests testing it on the remote control or the rear edge of the back cable cover first. The Devialet casing is made from cast aluminum, which is then machined and polished. After that, they apply a layer of copper, followed by chemical nickel plating. The advantages of chemical nickel plating is that the layer thickness is extremely even, it enters small gaps and layers sharp edges with the exact same thickness, plus it looks nice. However, it's susceptible to staining from fingerprints (and other substances), due to it not being a member of the so called precious metals. In other words, it reacts to acids among other. It's actually not that easily scratched per say, but due to the soft underlying material, thin layer and mirror finish, even the smallest scratch will show clearly.
I do not use glass cleaner, just because it will leave them very "dry" and non slippery, which increase the risk of scratching. Any car detailing nerd will know this Wink.
I also never use anything paper based, because it will scratch. You might not be able to see it, yet, but there will be scratches eventually.

I clean and protect mine like this:
First I dust them with canned compressed air (usually it's nitrogen), to remove any big/heavy particles. Keep the can upright, or it will spray liquid nitrogen and it may stain and is dangerously cold.
Then remove the last and finest remaining dust with a duster that has microfiber bristles, followed by a clean(!) microfiber cloth.
If there are stains, just continue with the following steps.
-The following steps require that they are unplugged, to be at ambient temperature-
If there are any stains, I remove them with DI water and 99.7% pure ethanol (not the kind with denaturing agents), about 50/50% mix on a clean(!) waffle surfaced microfiber cloth, carefully. Not really rubbing, but just wiping. I end with turning the cloth, so I can wipe it dry. Any stains should be gone now.
You're now left with a stain- and streak free surface, if the products and cloths used are good quality. However, the surface is also very "dry" and non slippery, so there is a risk of scratching when dusting them next time. Avoid using regular "fluffy" microfiber cloths until the final step below, since microfibers might come loose and stick to the nickel surface. Use the waffle type.
I've tried a handfull of different quick detailers for car paints, sometimes called wiping solutions or wiping agents, but all but one left greasy looking marks (that could be removed with the above said DI water + ethanol mix, but left the surface bare again). The only one that worked for me, was a product called Orchard AutoCare Perfection. It makes the surface rather slippery, but it's not visible.
Spray it onto the surface and wipe/buff until dry and streak free, with a fluffy high quality (clean!) microfiber cloth. Finalize by turning the cloth over, to an unused side and buff completely dry.
Since the Devialet is hopefully being kept inside, the treatment will last for months.

I can also recommend the Orchard products for your car. However, I am not affiliated with them in any way and will not give any specific recommendations, since paint is even more sensitive than nickel plating.

.::disclaimer - I will take no responsibility for any kind of damages, loss or similar issues, due to following, not fully following or not follwing the suggestions above::.
Ken - a new Devialet fan, located in Sweden  Cool
Reply


Messages In This Thread
Cleaning the Devialet - by Confused - 28-Sep-2014, 10:14
RE: Cleaning the Devialet - by GuillaumeB - 28-Sep-2014, 10:57
RE: Cleaning the Devialet - by darthsteph - 28-Sep-2014, 12:27
RE: Cleaning the Devialet - by moreno1973 - 28-Sep-2014, 19:49
RE: Cleaning the Devialet - by Rufus McDufus - 28-Sep-2014, 20:30
RE: Cleaning the Devialet - by Axel - 09-Nov-2014, 15:36
RE: Cleaning the Devialet - by Pim - 29-Sep-2014, 06:38
RE: Cleaning the Devialet - by chrish - 07-Oct-2014, 19:36
RE: Cleaning the Devialet - by krass - 07-Oct-2014, 19:43
RE: Cleaning the Devialet - by darthsteph - 07-Oct-2014, 21:20
RE: Cleaning the Devialet - by mauidan - 01-Dec-2014, 19:31
RE: Cleaning the Devialet - by agentsmith - 05-Dec-2014, 02:35
RE: Cleaning the Devialet - by Pim - 05-Dec-2014, 03:32
RE: Cleaning the Devialet - by agentsmith - 05-Dec-2014, 04:54
RE: Cleaning the Devialet - by darthsteph - 05-Dec-2014, 23:14
RE: Cleaning the Devialet - by simplicate - 30-Dec-2014, 06:14
RE: Cleaning the Devialet - by Pim - 30-Dec-2014, 06:53
RE: Cleaning the Devialet - by weust - 30-Dec-2014, 13:23
RE: Cleaning the Devialet - by Mikeeo - 31-Dec-2014, 09:39
RE: Cleaning the Devialet - by KenH - 09-Jul-2018, 14:42

Forum Jump:


Users browsing this thread: 2 Guest(s)